Docstoc

7-LIQUID SHOCK - PDF

Document Sample
7-LIQUID SHOCK - PDF Powered By Docstoc
					U.S. DEPARTMENT OF LABOR
Occupational Safety and Health Administration

MATERIAL SAFETY DATA SHEET
SECTION I
Manufacturer’s Name: Chem Lab Products, Inc. Emergency Telephone No.: (909) 390-9912 / (800)424-9300(CHEMTREC) Address(No./Street/City/State/Zip code) 5160 E. Airport Drive, Ontario, CA 91761 Chemical Name and Synonyms: Sodium Hypochlorite, Bleach Trade Name and Synonyms: Spa Kem LIQUID SHOCK Chemical Family: Alkali Hypochlorite Formula: NaOCl CAS #07681-52-9 NFPA Rating: Health: Flammability: Reactivity: Special: ( ) DOT Proper Shipping Name: Consumer commodity III DOT Hazard Class: ORM-D Package Group: DOT ID Number: N/A

SECTION II – HAZARDOUS INGREDIENTS
HAZARDOUS MIXTURES OF OTHER LIQUIDS, SOLIDS, GASES SODIUM HYPOCHLORITE ( 7681-52-9:UN1791) SODIUM HYDROXIDE (1310-73-2;UN1823) % 5.25% 0.5%

SECTION III – PHYSICAL DATA
FREEZING POINT BOILING POINT (Deg. Fahrenheit) SPECIFIC GRAVITY (H2O)=1) pH VAPOR PRESSURE (cm Hg.) PERCENT VOLATILE BY VOLUME (%) EVAPORATION RATE (____=1) VAPOR DENSITY (Air = 1) 20 º 218 º 1.16-1.18 12 Variable Variable N/A N/A DECOMPOSITION TEMPERATURE BULK DENSITY (loose) pH (in 1% solution) SOLUBILITY IN WATER MOLECULAR WEIGHT APPEARANCE ODOR N/A N/A N/A N/A

74.45 Light Yell-Green Chlorine odor

SECTION IV – FIRE AND EXPLOSION HAZARD DATA
FLASH POINT FLAMMABLE LIMITS EXTINGUISHING MEDIA SPECIAL FIRE FIGHTING PROCEDURES UNUSUAL FIRE AND EXPLOSION HAZARDS Nonflammable N/A Flood with water or Carbon Dioxide (CO2) Must wear NIOSH certified gas mask with canister for chlorine. Material is strong oxidizer; contact with combustibles may initiate or promote combustion. Acid and heat accelerate decomposition. Decomposition PRODUCTS may include chlorine.

SECTION V – HEALTH HAZARD DATA
THRESHOLD LIMIT VALUE N/A EFFECTS OF INGESTION - causes irritation of the mouth, throat, and stomach. SKIN - severe OVEREXPOSURE irritation. INHALATION - severe irritation. EYE - severe irritation. IF SWALLOWED: Drink large quantities of milk or gelatin solution, or if these are not available, drink EMERGENCY large quantities of water. Do not give vinegar or other acids. Do not induce vomiting. Get prompt AND medical attention. IF IN EYES: Flush with a steady, gentle stream of water for 15 minutes. Get FIRST AID medical attention. IF ON SKIN: Wash with plenty of soap and water. IF INHALED: Remove victim to PROCEDURES fresh air. Call physician if exposure is severe.

Created by Dana Somesla

Page 1 of 2

March 29, 1999

CHEM LAB SKU # 262

SECTION VI – REACTIVITY DATA
Light, heat, fire, low pH, metallic impurities, naturally decomposes with age. Acid, ammonia, amines, cyanides, chlorinated isocyanurates, INCOMPATIBILITY (Materials to avoid) combustibles, detergents, reducing agents, oxidizable materials. HAZARDOUS DECOMPOSITION Contact with acid will releases chlorine gas; natural decomposition Products is PRODUCTS oxygen. Thermal decomposition or burning may produce HCI. HAZARDOUS MAY OCCUR CONDITIONS None Known POLYMERIZATION TO AVOID WILL NOT OCCUR X STABILITY UNSTABLE STABLE X CONDITIONS TO AVOID

SECTION VII – SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN Material is toxic to fish. Contain in diked area. Neutralize with sodium sulfite, sodium CASE OF MATERIAL thiosulfate, or ferrous salt solutions. Dilute copiously with water. RELEASED OR SPILLED WASTE This pesticide is toxic to fish. Keep out of lake, streams, ponds, and public waters. Treated effluent cannot DISPOSAL be discharged into lakes, steams, or ponds unless a discharge permit is obtained. For guidance, contact METHOD the regional office of the Environmental Protection Agency.

SECTION VIII – SPECIAL PROTECTION INFORMATION
Use MSHA-NIOSH approved respirator for dusts, mists, and fumes with TLV not less than .05 mg/m3 VENTILATION LOCAL EXHAUST Desirable SPECIAL MECHANICAL (General) OTHER PROTECTIVE GLOVES: Rubber gloves EYE PROTECTION: Chemical goggles OTHER PROTECTIVE EQUIPMENT: Rubber splash apron. Safety shower and eyewash should be located nearby. RESPIRATORY PROTECTION (Specify type)

SECTION IX – SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING OTHER PRECAUTIONS Store upright in cool, day area away from direct sunlight and excessive heat. Do not store near other incompatible household PRODUCTS. Do not store next to Acid. Rinse empty container thoroughly with plenty of water. Do not contaminate food, feed, or water by store, disposal, or cleaning of equipment. Wash contaminated clothing before reuse. Discard contaminated shoes.

This data is offered in good faith as typical values and not as a Products specification. No warranty, either expressed or implied, is hereby made. The recommended industrial hygiene and safe handling procedures are believed to be generally applicable. However, each user should review these recommendations in the specific context of the intended use and determine whether they are appropriate.

Created by Dana Somesla

Page 2 of 2

March 29, 1999

CHEM LAB SKU # 262


				
DOCUMENT INFO
Shared By:
Categories:
Tags:
Stats:
views:8
posted:7/22/2009
language:English
pages:2