Document Sample
hst Powered By Docstoc
					SATELLITE CITY • SIMI VALLEY, CA • (805) 522-0062 ISSUED 09/01/08 HOT STUFF - SUPER’T’ (Yellow Label) Cat#s (HST) 1/4, 1/2, 1, 2 4 and 16


1(860) 5715100
Refer to Item:


1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Product Name: 17426 Satellite City Gap Filling Inst Adh Item No.: 17426 Product Type: Cyanoacrylate Ester 2. COMPOSITION, INFORMATION ON INGREDIENTS Ventilation: Ingredients CAS No. 7085-85-0 9011-14-7 123-31-9 % 90-95 5-10 0.1-1 Respiratory Ethyl cyanoacrylate Poly (methyl methacrylate) HYDROQUINONE 8. EXPOSURE CONTROLS, PERSONAL PROTECTION Eyes: Skin: Safety glasses or goggles. Nitrile or polyethylene gloves and aprons. Do not use cotton. See supplemental page for additional information. Positive down-draft exhaust ventilation should be provided to maintain vapor concentration below TLV. Not available See Section 2 for Exposure Limits. 9. PHYSICAL AND CHEMICAL PROPERTIES OTHER Appearance: Clear liquid Odor: Sharp, Irritating Boiling Point: More than 300°F pH: Does not apply Solubility in Water: Polymerized by water. Specific Gravity 1.0156 at 77°F Volatile Organic Compound (EPA Method 24) 87.1%; 914.55 g/l 4.10% 41.6 grams per liter of material (California SCAQMD Method 316b) Vapor Pressure: Less than 0.2mm at 75°F Vapor Density: Approximately 3 Evaporation Rate (Ether = 1) Not available 10. STABILITY AND REACTIVITY Stability: Stable Hazardous Polymerization: Will not occur Incompatibility: Polymerized by contact with water, alcohols, amines, alkalies. Conditions to Avoid: Not available Hazardous Decomposition Products (non-thermal): None 11. TOXICOLOGICAL INFORMATION Ingredients Literature Referenced Carcinogen Target Organ and Other Health Effects NTP IARC OSHA See Section 3. 12. ECOLOGICAL INFORMATION No data available 13. DISPOSAL CONSIDERATIONS Recommended methods of disposal: Polymerize as above. Incinerate following EPA and local regulations. EPA Hazardous Waste Number NH - Not a RCRA Hazardous Waste Material 14. TRANSPORTATION INFORMATION DOT (49 CFR 172) Domestic Ground Transport Proper Shipping Name: Unrestricted (Not more than 450 liters); Combustible liquids, n.o.s. (Cyanoacrylate ester) (More than 450 liters) Hazard Class or Division: Unrestricted (Not more than 450 liters) Combustible liquid (More than 450 liters) Identification Number: None (Not more than 450 liters); NA 1993 (More than 450 liters) Marine Pollutant: None IATA Proper Shipping Name: Unrestricted (Not more than one pint); Aviation regulated liquid, n.o.s., (Cyanoacrylate Ester) (More than one pint) Class or Division: Unrestricted (Not more than one pint); Class 9 (More than one pint) UN or ID Number: None (Not more than one pint) UN 3334 (More than one pint) 15. REGULATORY INFORMATION CA Proposition 65: No Prop65 Chemicals known to be present. NFPA is a registered trademark of the National Fire Protection Assn.

Ingredients which have exposure limits Exposure Limits (TWA) Ingredients Ethyl cyanoacrylate HYDROQUINONE ACGIH OSHA (TLV) (PEL)

0.2 ppm TWA None None 2 mg/m3 TWA 2 mg/m3 TWA 4 mg/m3 STEL

2 mg/m3 TWA

Exposure Limits (STEL) ACGIH OSHA Ingredients (TLV) (PEL) 3. HAZARDS IDENTIFICATION Toxicity: Skin contact may cause burns. Bonds skin rapidly and strongly. Skin and eye irritant. Estimated oral LD50 more than 5000mg/kg. Estimated dermal LD 50 more than 2000 mg/kg. Primary Routes of Entry: None known Signs and Symptoms of Exposure: Vapor is irritating to eyes and mucous membranes above TLV. Exposure to vapors above the established limits may cause symptoms of non-allergic asthma. Existing Conditions Aggravated by Exposure: None known

Ethyl cyanoacrylate ALG IRR RES NO NO NO Poly (methyl methacrylate) IRR NO N/A NO HYDROQUINONE BLO BNM CNS EYE IMM IRR LIV MUT NO N/A NO SKI THY Abbreviations N/A Not Applicable ALG Allergen BLO Blood BNM Bone Marrow CNS Central nervous system EYE Eyes IMM Immune system IRR Irritant LIV Liver MUT Mutagen RES Respiratory SKI Skin THY Thyroid 4. FIRST AID MEASURES Ingestion: Inhalation: Skin Contact: Eye Contact: Ingestion is not likely. See supplemental page for emergency procedures. Remove to fresh air. If symptoms persist, obtain medical attention. Soak in warm water. See supplemental page for emergency procedures. Flush with water. See supplemental page for emergency procedures.

5. FIRE FIGHTING MEASURES Flash Point: 150 - 200°F Method: Tag Closed Cup Recommended Extinguishing Agents: Carbon dioxide, foam, dry chemical Special Firefighting Procedures: Not available Hazardous Products formed by Fire or Thermal Decomp Irritating organic fragments. Unusual Fire or Explosion Hazards: None Explosive Limits: (% by volume in air)Lower Not available (% by volume in air)Upper Not available 6. ACCIDENTAL RELEASE MEASURES Steps to be taken in case of spill or leak: Flood with water to polymerize. Soak up with an inert absorbent. 7. HANDLING AND STORAGE Safe Storage: Handling: Store at or below 75 deg. F Avoid contact with skin and eyes. Avoid breathing vapor.


Estimated NFPA(R) Code: Health Hazard: 2 HMIS is a registered trademark of the Fire Hazard: 2 National Paint and Coatings Assn. Reactivity Hazard: 1 Specific Hazard: Does not apply Health Hazard: 2 Flammability Hazard: 2 Reactivity Hazards: 1 Personal Protection: See Section 8. NFPA is a registered trademark of the National Fire Protection Assn. HMIS is a registered trademark of the National Paint and Coatings Assn. Prepared By: Stephen Repetto Title: Research Chemist, Environmental Health & Safety Company: Loctite Corp., 1001 Tr Br Cr, Rocky Hill CT 06067 (24hr.) Phone: (860) 571-5100 Revision Date: January 26, 1999 Revision: 0032

'U!IS papuoq {;lelueprcce e}eredos ol poq}aur cr}se.rp e qcns osn ol fuessacau oq Jenou plnoLls }l AUf 9U NS

'anoqe poqucsop sp ensstl aql uoll peseelol st e1e;{lceouelc 'urnq e esnpc o1 qbnoue etn}eredure} 1o durnl oql loile {;leulou pe}eor} eq plnoL.ls sulnE ut ose€Jcur l1rnn dorp eblel e sesec eJeJ ul 'uouecrlrprlos uo leoq llo enr0 selel{iceoue{3 SNHNs
'seL,lcetep lt uot,lM durnl eLll lo uorlseOur luenerd ol tuelted eLll uotltsod 'q1nou.t oLll u! srurol dunl e esec ul 'sAep oml ol lleq auo u! a^lsal,lpe oql llll lllm e^lles 'qlnou eql ut sejeqpe pue selilpllos e^tsoLlpe oql 'elelrfuceoue{c MolleMs ol elqlssodutt }soujle sl }l

'uouce 6ulsoddo lcoltp qlran sdtl eqt llnd ol ful lou oC 'uede sdtl 11ol lo lood 'Lllnou or.lleplsur e^rles uroll oJnssord pue Oulllenn unutxeui ebernocua pue sdrl eq1 ol lolem ulrem lo slol A;dde 'req1e0o1 lcnls {gle1uep;cce a)e sdll Jl HlnOt/\l 'uorleutureluoc ssoJ0 tllltvt ueno 'slnoq lo Jolleu e utqllm Jncoo {11euuou lllM uol}ercossesrp }eq} ozlleol pue esnes-ell} pue}s -repun ol lueuodurt si tt pue 'lcalle fuoler.u{rqcel e qllm ror.lle6o} pecueue-dx? eq Aeu uotstn elqnop tuorleugureiuoc 1o poried eq1 6uun6 'po^orqo_e st ocueleolo ltlun buldaenn;o spotted osnec lllm slql 'sJnoq lelo^os Ouuenoc {1gereueO 's-poqred luolutulo}ut le^o }l tuoll ai9l3 -ossestp lltM pue'[letold ilr{e eqt ol lles}l r{oepe;1rnn se{e oLl} olu! pocnpor}ur a1e1fuceoueA3 ]]VBS S f HI NO :IAIS:IHCV
'uorlelndrueul [q se{e er]} uedo ol Ar} lou oO _'e6euep lenp!ser o^u oq l[lM aJoL]I 's{ep 7-P ur ,{lgdcrcir{1 'uor15e loL1Un} }noq}rM uedo 11rnn e{e eq1 'qc1ed ezne6 e Aldde puP JeleM Lurem 'qirnnAlq$no;oql qsem'11eqe{e oq} o} popuoq ro reqle6o} IOn}s eie spt;eAe }eq} }ue^e oq} uN NOISf HOV llv8f Af HO Cll:lAf Ol OllSAf 'uorlse 6ursoddo lceltp e Llllm Uede socellns 11nd o1 {.t} }ou oC 'Jal_eM pue deos L1}tM utIS oq} uo.l} o^tsor.lpe enourel uor-ll ielpueq uoodseele ro elnleds e '6'e 'e6pe lunlq e lo pte oql qllm UBde socepns or.,ll llol Jo leod 'Jolem [deos 'ulrem ur socelns popuoq oq] ostotutut ]slll NOIS:IHOV NIYS
'onrseL1pe lo slunoue ebre; Ourlpueq uaqm uotde pue sanolb euel{q1eA1od Jo olrl}ru JeoM 'sroden 6ur1e1utt '6uot1s pue 'sulnq ulIS 'olgulq 6ursnec leoL{ o}ploue6 ;pnn entseLlpe 1o slunouue e6te;_1o uot}eztJau{god eq1 'uorlezueur{god osnec {eur sleue}et! osoql q}lm }ce}uoC 'onssr} ro 'sber 'sorJqe} 'soq}olc tl}tm }celuoc ptony

'urIs eL{} o} pepuoq ueqm uano p)eze1 qlleoLl e lueserd lou soop e^rsoLlpe pelnO'slnoq lelo^as ut u-tlS eLlI ur IeoS 'o^rsot{pe ssocxo e^oLUoH u.rorl€soot ouroc lr^^ o^rsaqpe aqt


'Moloq uent0 -o1e slueptcce lo sed& c11;ceds lo luoullpell 'prp lslll ;ectbrnsuou 'entssed {q lseq pelpueLl ere sbteifuceoler(c ot en'p slueprcce leLll umoqs seq ecueuedx3 'spuocos ul ullq butpnlc-ur ensstl upunq spuoq ll 'a^rsoqpe 6uoris pue Ourpes lsel ften e st e^tsoqpe elel{tceoue{3

epuog luelsul


fuZVZi gl7

:urelt ol ro+ou

.. -IVIN3[ l:t'lddns z o6ed oo I:I:I HS VIVC AI3JVS'IVIHf IVIA'I
2900'zz9 (gog)

0o re


tzg (oge)

. v3 X3ttv

tt/\ts . A1l3


Shared By: