8100 - PDF

Document Sample
8100 - PDF Powered By Docstoc
					10042007

MATERIAL SAFETY DATA SHEET : 00000752
NATIONAL CHEMSEARCH DIV. OF NCH CANADA INC. 245 ORENDA ROAD. BRAMPTON, ONTARIO L6T 1E7 CHEMTREC 1-800-424-9300

PAGE:1

PRODUCT : NC-123 PLUS AEROSOL

SECTION 01: MANUFACTURER INFORMATION
MANUFACTURER.....................NATIONAL CHEMSEARCH DIV. OF NCH CANADA INC. 245 ORENDA ROAD. BRAMPTON, ONTARIO ; L6T 1E7 CHEMTREC 1-800-424-9300 1-800-387-1784 WHMIS CLASS......................A. B5. D2b NFPA - HEALTH RISK...............1 = SLIGHT NFPA - FLAMMABILITY..............4 = EXTREME NFPA - REACTIVITY................0 = INSIGNIFICANT MATERIAL CODE....................5625 PRECAUTIONS......................KEEP AWAY FROM OPEN FLAMES, SPARKS, OR IGNITION SOURCES.

SECTION 02: HAZARDOUS INGREDIENTS
HAZARDOUS INGREDIENTS ALIPHATIC PETROLEUM DISTILLATES BARIUM SULFONATE BUTANE PROPANE % 75-80 1-5 5-10 10-15 EXPOSURE LEVELS 100 PPM 0.5 MG/M3 1000 PPM 1000 PPM C.A.S. # 64742-47-8 61790-48-5 106-97-8 74-98-6 LD/50, ROUTE, SPECIES ORL-RAT >5,000 MG/KG SKN-RBT >3,160 MG/KG NOT ESTABLISHED NOT ESTABLISHED NOT ESTABLISHED LC/50, ROUTE, SPECIES IHL-RAT >5.2 MG/L/4H NOT ESTABLISHED IHL-RAT 658 G/M3/4H IHL >40% BY VOLUME

SECTION 03: PHYSICAL DATA
PHYSICAL STATE...................AEROSOL ODOUR............................SOLVENT ODOUR COLOUR...........................AMBER VISCOSITY........................NON-VISCOUS CLARITY..........................TRANSPARENT VAPOUR PRESSURE (mm Hg)..........1273 VAPOUR DENSITY (AIR=1)...........1.9 BOILING POINT (deg C)............148 EVAPORATION RATE.................21.9 pH...............................NOT APPLICABLE PERCENT VOLATILE BY VOLUME.......92 SPECIFIC GRAVITY.................0.74 SOLUBILITY IN WATER (% W/W)......NEGLIGIBLE

SECTION 04: FIRE & EXPLOSION DATA
FLAMMABILITY.....................EXTREMELY FLAMMABLE IF YES, UNDER WHICH..............EXCESSIVE HEAT, SPARKS, AND OPEN FLAME. CONDITIONS? EXTINGUISHING MEDIA..............CARBON DIOXIDE, DRY CHEMICAL, FOAM, WATER SPECIAL PROCEDURES...............FIREFIGHTERS SHOULD WEAR A SELF-CONTAINED BREATHING APPARATUS AND FULL PROTECTIVE GEAR. COOL FIRE-EXPOSED CONTAINERS WITH WATER SPRAY TO PREVENT BURSTING. VAPOURS ARE HEAVIER THAN AIR AND MAY TRAVEL TO DISTANT SOURCES OF IGNITION AND FLASHBACK. USE CARE AS SPILLS MAY BE SLIPPERY. PRODUCT MAY PRODUCE A FLOATING FIRE HAZARD AS LIQUID FLOATS ON WATER. UNUSUAL FIRE AND EXPLOSION.......FLAME EXTENSION = > 24 INCHES (61 CM). BURNBACK = 4 INCHES (10 CM) HAZARDS FLASH POINT (C)..................41 FLASH POINT METHOD...............SETAFLASH FLAMMABLE LIMITS.................PRODUCT MIXTURE LOWER FLAMMABLE LIMIT (% VOL)....0.8 UPPER FLAMMABLE LIMIT (% VOL)....9.5 HAZARDOUS COMBUSTION PRODUCTS....ALDEHYDES. OXIDES OF BARIUM. OXIDES OF CARBON (CO,CO2)

SECTION 05: REACTIVITY DATA
CHEMICAL STABILITY YES........................STABLE, HAZARDOUS POLYMERIZATION WILL NOT OCCUR NO, WHICH CONDITIONS ?.....HEAT, HOT SURFACES, SPARKS, AND OPEN FLAMES. COMPATIBILITY WITH OTHER SUBSTANCES YES NO, WHICH ONES?............STRONG OXIDIZING AGENTS SUCH AS CHLORINE BLEACH AND CONCENTRATED HYDROGEN PEROXIDE.

10042007

MATERIAL SAFETY DATA SHEET : 00000752

PAGE:2

PRODUCT : NC-123 PLUS AEROSOL
SECTION 06: TOXICOLOGICAL PROPERTIES
ROUTE OF ENTRY: SKIN CONTACT...............CAUSES IRRITATION SEEN AS ITCHING, REDNESS, AND A BURNING SENSATION. INJECTION UNDER THE SKIN, IN MUSCLE, OR INTO THE BLOOD STREAM CAN CAUSE IRRITATION, INFLAMMATION, SWELLING, FEVER, SYSTEMIC EFFECTS, AND MILD CENTRAL NERVOUS SYSTEM DEPRESSION. HIGH PRESSURE INJECTION OF HYDROCARBONS UNDER THE SKIN CAN CAUSE SEVERE, PERMANENT TISSUE DAMAGE. INITIAL SYMPTOMS MAY BE MINOR. PROLONGED OR REPEATED CONTACT AS FROM CLOTHING WET WITH MATERIAL MAY CAUSE DRYING, DEFATTING, AND CRACKING OF THE SKIN. EYE CONTACT................CAUSES IRRITATION SEEN AS STINGING, TEARING, REDNESS, AND A BURNING SENSATION. INHALATION.................MAY CAUSE RESPIRATORY IRRITATION SEEN AS COUGHING AND SNEEZING. AT LOW VAPOUR CONCENTRATIONS, NO HARMFUL EFFECTS ARE EXPECTED. AT HIGH VAPOUR CONCENTRATIONS, INHALATION MAY CAUSE CENTRAL NERVOUS SYSTEM EFFECTS SUCH AS HEADACHE, DIZZINESS, DROWSINESS, WEAKNESS, UNCONCIOUSNESS, POSSIBLE ANESTHETIC EFFECTS FROM CENTRAL NERVOUS SYSTEM DEPRESSION, AND MAY BE FATAL. INGESTION..................MAY CAUSE IRRITATION WITH POSSIBLE NAUSEA, VOMITING, AND DIARRHEA. THIS PRODUCT CONTAINS BARIUM COMPOUNDS, WHICH UPON INGESTION MAY BE METABOLIZED BY THE BODY TO FORM BARIUM CHLORIDE, A TOXIC MATERIAL. SYMPTOMS INCLUDE ACUTE GASTROENTERITIS, LOSS OF DEEP REFLEXES, PROSTRATION, MUSCLE TREMORS, MUSCULAR PARALYSIS RELATED TO SEVERE HYPOKALEMIA , RESPIRATORY FAILURE, AND CARDIAC ARREST. INGESTION AND SUBSEQUENT VOMITING OF THIS PRODUCT CAN LEAD TO ASPIRATION OF THE PRODUCT INTO THE LUNGS WHICH CAN CAUSE DAMAGE AND MAY BE FATAL. EFFECTS OF CHRONIC EXPOSURE......ON RARE OCCASIONS, PROLONGED AND REPEATED EXPOSURE TO HYDROCARBON OR OIL MIST POSES A RISK OF CHRONIC LUNG INFLAMMATION. THIS CONDITION IS USUALLY ASYMPTOMATIC AS A RESULT OF REPEATED SMALL ASPIRATIONS. SHORTNESS OF BREATH AND COUGHING ARE THE MOST COMMON SYMPTOMS. ASPIRATION MAY LEAD TO PULMONARY EDEMA AND HEMORRHAGE AND MAY BE FATAL. SIGNS OF LUNG INVOLVEMENT INCLUDE INCREASED RESPIRATION AND HEART RATES AS WELL AS A BLUISH DISCOLOURATION OF THE SKIN. CHRONIC SKIN CONTACT MAY PROMOTE DERMATITIS AND OIL ACNE. IN RARER CASES, AN INCREASED SENSITIVITY TO SUNLIGHT (PHOTO-SENSITIVITY) MAY OCCUR. CHRONIC ABUSE OF SIMILAR MATERIALS HAS BEEN ASSOCIATED WITH IRREGULAR HEART RHYTHMS AND CARDIAC ARREST. MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE ARE PRE-EXISTING RESPIRATORY AND SKIN CONDITIONS SUCH AS ASTHMA, EMPHYSEMA, AND DERMATITIS. TARGET ORGANS....................CENTRAL NERVOUS SYSTEM. CARDIOVASCULAR SYSTEM. HEART. LIVER CARCINOGENICITY OF MATERIAL......NOT APPLICABLE PRIMARY ROUTE OF ENTRY...........INHALATION

SECTION 07: PREVENTIVE MEASURES
PROTECTIVE EQUIPMENT GLOVES/ TYPE...............NEOPRENE OR NITRILE RUBBER GLOVES IF REPEATED OR PROLONGED SKIN CONTACT IS LIKELY. RESPIRATORY/TYPE...........FOR CONCENTRATIONS ABOVE THE TLV AND/OR PEL BUT LESS THAN 10 TIMES THESE LIMITS, A NIOSH APPROVED HALF-FACEPIECE RESPIRATOR EQUIPPED WITH APPROPRIATE CHEMICAL CARTRIDGES MAY BE USED. FOR CONCENTRATIONS GREATER THAN 10 TIMES THE TLV AND/OR PEL, CONSULT THE NIOSH RESPIRATOR DECISION LOGIC FOUND IN PUBLICATION NO. 87-116 OR ANSI Z88.2-1992. EYE/TYPE...................SAFETY GLASSES WITH SIDE SHIELDS IF THE METHOD OF USE PRESENTS THE LIKELIHOOD OF EYE CONTACT. OTHER/TYPE.................WEAR GENERAL-DUTY WORK CLOTHES AND SHOES. REMOVE SOAKED CLOTHING AND SHOES. WASH CLOTHING AND CLEAN SHOES BEFORE REUSE. AN EYEWASH STATION AND SAFETY SHOWER SHOULD BE AVAILABLE. VENTILATION REQUIREMENTS.........LOCAL EXHAUST AT POINTS OF EMISSION. LEAK/SPILL.......................DUE TO THE NATURE OF THE AEROSOL PACKAGING, A LARGE SPILL IS UNLIKELY. WEAR APPROPRIATE PROTECTIVE CLOTHING. VENTILATE THE AREA. ABSORB WITH AN INERT MATERIAL AND TRANSFER ALL MATERIAL INTO A PROPERLY LABELED CONTAINER FOR DISPOSAL. USE CARE AS SPILLS MAY BE SLIPPERY. WASTE DISPOSAL...................DISPOSE OF IN ACCORDANCE WITH ALL FEDERAL, PROVINCIAL, AND LOCAL REGULATIONS. TYPICAL DISPOSAL IS TO WRAP THE EMPTY AEROSOL CONTAINER IN SEVERAL LAYERS OF NEWSPAPER AND DISPOSE OF IN THE TRASH. AEROSOL RECYCLING PROGRAMS ARE AVAILABLE IN MANY AREAS. DO NOT PUNCTURE OR INCINERATE THIS CONTAINER. PROCEDURES.......................STORE BETWEEN 2 & 49 C (35 & 120 F). USE WITH CAUTION AROUND HEAT, SPARKS, PILOT LIGHTS, STATIC ELECTRICITY, AND OPEN FLAME. KEEP OUT OF REACH OF CHILDREN. READ THE ENTIRE LABEL BEFORE USING THIS PRODUCT. FOLLOW THE LABEL DIRECTIONS.

SECTION 08: FIRST AID MEASURES
SKIN CONTACT.....................WASH AFFECTED AREAS WITH LARGE AMOUNTS OF SOAP AND WATER FOR 15 MINUTES. SEEK MEDICAL ATTENTION IF IRRITATION DEVELOPS. WASH CLOTHING AND CLEAN SHOES BEFORE REUSE. EYE CONTACT......................RINSE THE EYES WITH WATER. REMOVE ANY CONTACT LENSES AND CONTINUE FLUSHING WITH PLENTY OF WATER FOR SEVERAL MINUTES. SEEK MEDICAL ATTENTION IF IRRITATION DEVELOPS. INGESTION........................GIVE 3 TO 4 GLASSES OF WATER. DO NOT INDUCE VOMITING. IF VOMITING OCCURS, GIVE FLUIDS AGAIN. GET IMMEDIATE MEDICAL ATTENTION. DO NOT GIVE ANYTHING BY MOUTH TO AN UNCONSCIOUS OR CONVULSING PERSON. INHALATION.......................REMOVE FROM THE AREA TO FRESH AIR. SEEK MEDICAL ATTENTION IF RESPIRATORY IRRITATION DEVELOPS OR IF BREATHING BECOMES DIFFICULT.

10042007

MATERIAL SAFETY DATA SHEET : 00000752

PAGE:3

PRODUCT : NC-123 PLUS AEROSOL
SECTION 08: FIRST AID MEASURES
NOTES TO PHYSICIAN...............IN THE EVENT OF INJECTION IN UNDERLYING TISSUE, IMMEDIATE TREATMENT SHOULD INCLUDE EXTENSIVE INCISION, DEBRIDEMENT, AND SALINE IRRIGATION. INADEQUATE TREATMENT CAN RESULT IN ISCHEMIA AND GANGRENE. EARLY SYMPTOMS MAY BE MINIMAL. INGESTION AND SUBSEQUENT VOMITING OF THIS PRODUCT CAN LEAD TO ASPIRATION OF THE PRODUCT INTO THE LUNGS WHICH CAN CAUSE DAMAGE AND MAY BE FATAL. DEPENDING ON THE AMOUNT INGESTED AND RETAINED AS WELL AS THE TOXICITY OF THE PRODUCT, GASTRIC LAVAGE SHOULD BE CONSIDERED. KEEP PATIENT'S HEAD BELOW HIPS TO PREVENT PULMONARY ASPIRATION. IF COMATOSE, A CUFFED ENDOTRACHEAL TUBE WILL PREVENT ASPIRATION.

SECTION 09: PREPARATION INFORMATION
NOTICE...........................THE INFORMATION CONTAINED HEREIN IS BASED ON DATA CONSIDERED ACCURATE IN LIGHT OF CURRENT FORMULATION. HOWEVER, NO WARRANTY IS EXPRESSED OR IMPLIED REGARDING THE ACCURACY OF THIS DATA OR THE RESULTS TO BE OBTAINED FROM THE USE THEREOF. THE MANUFACTURER ASSUMES NO RESPONSIBILITY FOR PERSONAL INJURY OR PROPERTY DAMAGE CAUSED BY THE USE, STORAGE, OR DISPOSAL OF THE PRODUCT IN A MANNER NOT RECOMMENDED ON THE PRODUCT LABEL. USERS ASSUME ALL RISKS ASSOCIATED WITH SUCH UNRECOMMENDED USE, STORAGE, OR DISPOSAL OF THE PRODUCT. PREPARED BY......................MIKE MCDOWELL, HAZARD COMMUNICATION SPECIALIST 972-438-0125 PREPARATION DATE.................SEP 27/2007


				
DOCUMENT INFO
Shared By:
Categories:
Tags:
Stats:
views:16
posted:5/14/2009
language:English
pages:3