DNR-Introduction

Document Sample
DNR-Introduction Powered By Docstoc
					State of Wisconsin
Department of Natural Resources
Inquiry No. G-006-22

                            Wisconsin Department of Natural Resources

                                          SPECIFICATION - TABLE


There are two (2) specifications in this file for the following items:

                          1 Rock Island State Park Outboard Motors - Spec. No. 1
                          2 Rock Island State Park Vee-Hull Boat - Spec. No. 2

*(When printing the document, select file -> print -> select entire workbook, then OK)


Please complete the signature information below and attach with your specification sheets:


                            Company Name:

                        Company Address:




                     Authorized Signature:

                                       Date:
       WI-DNR: Spec. No. 1
       Inquiry No. G-006-22

                                               Wisconsin Department of Natural Resources
    Specifications No. 1 - Outboard Motor for welded aluminum, semi-vee landing craft boat
GENERAL INSTRUCTIONS:
Installation and sea trials shall be performed by the boat builder with at least two trails to be performed. The sea trials and operator training are to pe performed
at Jackson Harbor, Washington Island, WI. This may be done by the sucessful bidder or arranged through a local servicing dealer.


SPECIAL CONSIDERATIONS:
Dealer support for engines must be available on Washington Island. The vessel cannot be transported off from the island except by semi-trailer on a car ferry at
a cost of over $600.00 so the technicians will need to come to the island to service the engines or contract to a local dealer. This will be a primary vessel for
travel to Rock Island State Park by Rangers who are charged with visitor safety and protection there. Down time is a major concern if repairs are needed.
Reliability and rapid service are critical.


DELIVERY/INSTALLATION LOCATION:
Department of Natural Resources
Randy Holm, Operations Ranger
Rock Island State Park
1924 Indian Point Road
Washington Island WI
Phone: 920-847-2235



                DNR Motor Specifications                               Vender Motor Offered/Agreed

Motors: (Yamaha or Honda) - 2 units.
4-stroke outboard engines - one counter rotating the other

225 hoursepower each
30 inch shaft length
power trim and tilt
stainless steel propellers matched according to boat
builders specifications for a 32 foot aluminum vee hull
landing craft

                                                                                                                                                                        2
        WI-DNR: Spec. No. 1
        Inquiry No. G-006-22



                DNR Motor Specifications                    Vender Motor Offered/Agreed
binnacle control head
wiring harness
teleflex hydraulic steering
dual group 27 batteries
battery selection switch
tie bar
gauge package
steering package
3-year limited warrantee (1st year maintenance, warantee
work and inspection to be performed at no cost at Jackson
Harbor)



INSTALLED PRICE PER UNIT:




                                                                                          3
  WI-DNR: Spec. No. 2
  Inquiry No. G-006-22


                                            Wisconsin Department of Natural Resources
     Specifications No. 2 - Rock Island State Park - Welded Aluminum, Semi-Vee Landing Craft Boat
GENERAL DESCRIPTION:
Rock Island State Park is located on the Northeastern tip of the Door County penninsula of Wisconsin. Rock Island is at the navigational pasage between
the waters of Lake Michigan and Green Bay. The vessel we are seeking will transport equipment, supplies, and vehicles between Washington Island, WI
and the dock at Rock Island -- a distance of 1.5 miles. Weather at this location changes rapidly and rough water is encountered often due to high winds.
While staff would not transport heavy cargo in rough water it is important that the vessel be capable to safely handling 6 foot seas common on the lake. The
vessel is used from ice-out until the harbors freeze over in fall.


USAGE:
Will be used by construction crews to transport equipment, supplies, and vehicles between Washington Island WI and Rock Island WI. It will also be used to
load and haul a full-sized pickup truck.

DELIVERY LOCATION:
Department of Natural Resources
Randy Holm, Operations Ranger
Rock Island State Park
1924 Indian Point Road
Washington Island WI
Phone: 920-847-2235

                                                                                                                  Exceptions if Different than DNR
               DNR Vehicle Specifications                          Vender Specifications Offered                          Specifications


MINIMUM SPECIFICAITONS REQUIRED:

Welded aluminum, semi-vee hull landing craft design with
drive-on ramp-style bow door.
32 foot in length
10 foot beam with maximum beam no greater than 11 feet
(garage door opening is 11 ft.8in.)
32 degree V at entry-Packman Spec.-some variation
acceptable



                                                                                                                                                               4
  WI-DNR: Spec. No. 2
  Inquiry No. G-006-22

                                                                                                  Exceptions if Different than DNR
                DNR Vehicle Specifications                        Vender Specifications Offered           Specifications
16 degree V at Stern-Packman Spec.-some variation
acceptable
a 78 to 84 inch wide bow door opening for loading a pickup
or a 6-foot wide mower
Vessel shall be powered by twin 4-stroke 225hp Yamaha or
Honda outboard as part of this bid, with all steering controls,
guages, battteries normally included in the engine installation
(see attached motor bid specs)
motors shall be provided and installed by the successful
bidding boat manufacturer
Self bailing deck
Vessel must be capable of transporting a 19 foot full sized
pick-up truck
Raised aft pilot house 60 inches wide by 60 inches long
minimum with clear head room for a 6 foot tall person
Sliding windows on port and starboard sides of pilot house-
must open for ventilation
Sliding door with lock on the pilot house
2 forward fixed windows with electric wipers for each
No seats installed-pilot position will be standing, passenger
position should have a grab bar
Seat/storage locker across the rear of pilot house-for PFD's,
safety equipment, etc.
8 position 12 volt breaker installed on the console (minimum
number-more permitted as deemed necessary )

One combination red/white wheelhouse interior dome light
36 inch console minimum with room for gauges, GPS, radar
screen etc.
12 volt electric defroster fan on console
Navigation lights installed to meet Coast Guard specifications
for vessels operated on the Great Lakes
100 gallon or greater fuel tank
Racor fuel filters installed for each engine


                                                                                                                                     5
  WI-DNR: Spec. No. 2
  Inquiry No. G-006-22

                                                                                                 Exceptions if Different than DNR
                DNR Vehicle Specifications                       Vender Specifications Offered           Specifications
Engineered zinc anode protection for the hull and engines
Minimum of 2-15 inch x 24 inch water tight deck access
hatches installed capable of withstanding the load of a pickup
truck
Front tie down rails
10 inch spring line cleats installed midship to port and
starboard
side boarding door installed starboard side-for normal
boarding docks
12 volt electric bow door winch with a switch installed on the
console
3 inch or larger push knees installed both sides of bow door
4 inch tow post installed
1500 gallon per hour bilge pump will be automatic and
manual switches
12 volt bilge blower installed in fuel tank void
Bow door safety locks
Bow door rubber gasket seal
8 inch inspection hatches for all hull compartments
Minimum 1 1/4 pipe gunnel railings
Transom mounted transducer bracket with wire way
Trailer pad eye
Fuel line and engine control routing system
Steel painted yard trailer supplied and fitted for boat to
include lights, brakes, jack, winch, bunks
Deck and bow door to be coated with a noskid coating
Interlux 2000-E epoxy barrier with E-paint No Foul top coat
anti-fouling bottom paint
Completed boat to be launched and tested with operators
manual delivered with the boat




                                                                                                                                    6
 WI-DNR: Spec. No. 2
 Inquiry No. G-006-22

                                                                                            Exceptions if Different than DNR
              DNR Vehicle Specifications                    Vender Specifications Offered           Specifications
Warranty:

Minimum One (1) year warranty or manufacturers standard
warranty which ever is greater.

                            Cost for extended Warranty: $




                                                                                                                               7