IRGANOX 1010
PRODUCT DISTRIBUTED BY / PRODUIT DISTRIBUÉ PAR
Brenntag Canada Inc. WHMIS Number: 00068193
43 Jutland Road. Index: HCI7333/08A
Toronto, Ontario Effective Date: 2008 January 14
M8Z 2G6 Date of Revision: 2008 January 14
(416) 259-8231 Website: http://www.brenntag.ca
_______________________________________________________________________________________________
EMERGENCY TELEPHONE NUMBERS / EN CAS D'URGENCE
Toronto, ON (416) 226-6117 Montréal, QC (514) 861-1211 Winnipeg, MB (204) 943-8827
Edmonton, AB (780) 424-1754 Calgary, AB (403) 263-8660 Vancouver, BC (604) 685-5036
_______________________________________________________________________________________________
This document consists of an English and French MSDS.
Le présent document comprend une fiche signalétique en anglais et en français.
READ THE ENTIRE MSDS FOR THE COMPLETE HAZARD EVALUATION OF THIS PRODUCT.
LIRE LA FICHE SIGNALÉTIQUE EN ENTIER POUR UNE ÉVALUATION COMPLÈTE DES DANGERS QUE
REPRÉSENTE CE PRODUIT
Material Safety Data Sheet
WHMIS / ANSI Z400.1-2004 Compliant
Date / Revised: 01-14-2008 Release: 1.1
Product: IRGANOX 1010
1. Identification of the Substance/Preparation and of the Company/Undertaking
Company Information
Company: Ciba Canada Ltd.
2626 Argentia Road
Mississauga, Ontario L5N 5N2
Canada
Customer Service / Product Information: 1-866-679-2422
Emergency information
Emergency 24-Hour 24h: +1-800-873-1138
Health/Environmental Phone:
CANUTEC: (613) 996-6666 (24hrs)
Product information
Product: IRGANOX 1010
Use: stabilizer
2. Hazards Identification
Emergency overview
Signal word: NOTICE! !
Colour: White to off-white
Appearance: powder
State of matter: solid
Odour: odourless
Health: Dust may cause mechanical irritation to eyes and skin.
Physical/Chemical Refer to MSDS Section 7 for Dust Explosion information.
hazards:
Potential health effects
Primary routes of entry:
Skin, Inhalation, Eyes
Potential environmental effects
Low toxicity to aquatic organisms. Releases to the environment are to be avoided.
3. Composition/Information on Ingredients
This material does not contain any hazardous components that are reportable according to WHMIS criteria.
4. First-aid Measures
Inhalation:
Remove to fresh air, if not breathing give artificial respiration. If breathing is difficult, give oxygen and get immediate
medical attention.
Skin:
After contact with skin, wash immediately with plenty of water and soap.
Get medical attention if irritation occurs.
Eyes:
In case of contact with eyes, rinse immediately with plenty of water and seek medical advice.
Page: 1 / 6 000000016923
Material Safety Data Sheet
WHMIS / ANSI Z400.1-2004 Compliant
Date / Revised: 01-14-2008 Release: 1.1
Product: IRGANOX 1010
Ingestion:
Do not induce vomiting. If vomiting occurs naturally, have casualty lean forward to reduce the risk of aspiration.
Seek medical attention immediately.
Notes to physician:
None known
5. Fire-fighting Measures
Suitable extinguishing media:
carbon dioxide, dry powder, foam, water fog
Hazardous combustion products:
Burning may produce toxic combustion products.
Hazards during fire-fighting:
Standard procedure for chemical fires.
The product can form an explosive dust/air mixture. For further information, see Section 7 Explosion Hazards.
Protective equipment for fire-fighting:
Wear self-contained breathing apparatus and chemical-protective clothing.
6. Accidental Release Measures
Cleanup:
Sweep up and shovel into suitable containers for disposal.
Avoid raising dust.
Wear suitable protective equipment.
Should not be released into the environment.
7. Handling and Storage
Handling
General advice:
As with all industrial chemicals, use good industrial practices when handling. Avoid eye, skin, and clothing contact.
Do not inhale. Do not taste or swallow. Use only with adequate ventilation.
Protection against fire and explosion:
Combustible powder. - Avoid creating dusty conditions. - Grounding is required when emptying into a conductive
container. - When flammable solvents are present, the container must be inerted or the system otherwise designed
to prevent or contain an explosion. Seek expert advice. In addition, for products packaged in fused-lined (coated)
fiber drums, fiber drums with conductive liners, steel drums, steel pails, and Type " C " FIBC (bulk bags), or other
conductive the following instructions also apply: - Always ground this package before emptying. The user is
responsible for designing the system to handle solid and ensuring proper training of employees in the system's use.
Storage
General advice:
Keep container tightly closed in a dry, cool and well-ventilated place.
> for industrial use only 350 °C
Dust explosion class: Heavy Dust (20 lt ball at 10'000 Joule)
Explosion. (2)
Melting point: 110 - 125 °C
Boiling point: Not applicable
Vapour pressure: 0.13 nPa ( 20 °C)
Density: 1.15 g/cm3 ( 20 °C)
Vapour density: Not tested
Partitioning coefficient n- 23 (OECD 107/EC A.8) calculated
octanol/water (log Pow):
Viscosity, dynamic: Not applicable
% Volatiles: 0.5 %
Solubility in water: 5,000 mg/kg
Page: 3 / 6 000000016923
Material Safety Data Sheet
WHMIS / ANSI Z400.1-2004 Compliant
Date / Revised: 01-14-2008 Release: 1.1
Product: IRGANOX 1010
Acute inhalation toxicity:
No deaths or substance-related symptoms were recorded.
Acute dermal toxicity:
LD50 / dermal / rat: > 3,160 mg/kg
Skin irritation:
(Rabbits) Not an irritant.
Eye irritation:
(Rabbits) Not an irritant.
Skin Sensitization:
RIPT (Humans): Not an irritant or a sensitizer. under the conditions of the study, which involved testing of
a 0.5% w/v solution in dimethyl phthalate. (Guinea pig) Maximization test: Not a sensitizer.
Subchronic Toxicty:
The test substance was administered by incorporation into the diet to albino rats at concentrations of 0, 2,000,
10,000 and 50,000 ppm for 90 days. No significant abnormalities were seen among parameters such as growth,
food consumption, mortality, behavioral patterns, hematology, clinical blood chemistry, urinalysis, organ weight data
and gross and microscopic pathology. The no-observable effect level (NOEL) was 50,000 ppm, equivalent to 2,500
mg/kg/day. The test substance was administered by incorporation into the diet to groups of Beagle dogs at
concentrations of 0, 1,000 and 10,000 ppm for 3 months. There were no deaths during the study. Growth rates and
food consumption were within normal limits in all groups. There were no relevant changes in laboratory
parameters(hematology, clinical chemistry and urinalysis) and no treatment related changes were seen at autopsy
or on histopathological examination. The NOEL was 10,000 ppm, corresponding to an average intake of 322
mg/kg/day.
Subacute toxicity:
not determined
Genetic toxicity:
Ames Test: negative
Mouse dominant lethal: Negative.
(Chinese hamsters) Nucleus anomaly test: Negative
(Chinese Hamster)
Chromosomal Aberration Assay: Negative
(Somatic cells)
Ames Test: negative
Dominant lethal study: Non-mutagenic
Nucleus anomaly test in somatic interphase nuclei (Chinese hamster): Negative.
Carcinogenicity:
No treatment related changes were seen in any of the measured endpoints, including tumor formation. The NOEL
was 10,000 ppm, equivalent to approximately 116 mg/kg/day.
None of the components in this product at concentrations greater than 0.1% are listed by IARC; NTP, OSHA or
ACGIH as a carcinogen.
Reproductive toxicity:
The test substance was added to the diet of Charles River rats at levels of 0, 1,000, 3,000 and 10,000 ppm
throughout two generations. No death occurred amongst adult animals of either the FO or F1 generation norwere
there any consistent effects which could be attributed to the treatment. There were no adverse effects on litters of
treated parents in either generation. The findings of this study indicate that, under the conditions of the test, the
treated animals showed no substantial differences from their control counterparts and that their reproductive
capacity was not impaired.
Developmental toxicity/teratogenicity:
No evidence of teratogenic or embryotoxic effects when pregnant rats and mice were dosed at levels up to and
including 1000 mg/kg by gavage from day 6 through 15 of pregnancy.
Page: 4 / 6 000000016923
Material Safety Data Sheet
WHMIS / ANSI Z400.1-2004 Compliant
Date / Revised: 01-14-2008 Release: 1.1
Product: IRGANOX 1010
Neurotoxicity:
Not determined
12. Ecological Information
Toxicity to fish:
Brachydanio rerio/96 h/LC50: > 100 mg/l (OECD Guide-line 203)
Toxicity to aquatic invertebrates:
Daphnia magna/24 h/EC50: > 86 mg/l (OECD 202)
The tested concentration is well above its water solubility
Toxicity to aquatic plants:
Scenedesmus sp./72 h/EC50: > 100 mg/l (Guideline 92/69/EEC, C.3)
Toxicity to microorganisms:
activated sludge/3 h/IC50: > 100 mg/l (OECD 209)
Biodegradation:
Test method: OECD 303A
Degree of elimination: 45 % (28 Days)
Evaluation: Eliminated
Test method: OECD 301B
Degree of elimination: 5 % (28 Days)
Evaluation: Not readily biodegradable.
Bioaccumulation:
OECD Guideline 305 C
Bioconcentration factor: pour usage industriel uniquement 350 °C
inflammation:
classe d'explosion des forte explosion de (sphère de 20 litres à 10'000 Joule)
poussières: poussières (2)
Point de fusion: 110 - 125 °C
Point d'ébullition: non applicable
Pression de vapeur: ( 20 °C)
Densité: 1.15 g/cm3 ( 20 °C)
Densité de vapeur: non testé
Coefficient de partage n- 23 (OCDE 107/CE A.8) calculé(e)
octanol/eau (log Pow):
Viscosité dynamique: non applicable
% Volatil: 0.5 %
Solubilité dans l'eau: 5,000 mg/kg
toxicité aiguë par inhalation:
On n'a noté aucune mort ni aucun symptôme relié à la substance.
toxicité aiguë dermique:
DL50 / par voie cutanée / rat: > 3,160 mg/kg
Irritation de la peau:
(Lapins) N'est pas un irritant.
Irritation des yeux:
(Lapins) N'est pas un irritant.
Sensibilisation de la peau:
TEAR (humains): Non irritant ni sensibilisant. aux conditions de l'étude, des formulations de phtalate de
diméthyle à0,5 % (p/v) n'ont révélé aucun indice de sensibilisation. Test de maximisation (cobaye): Non
sensibilisant.
toxicité subchronique:
Le produit à l'essai a été administré à des rats albinos pendant 90 jours, à raison de 0, 2 000, 10 000 et 50 000
ppm incorporés dans le régime alimentaire. Aucune anomalie significative n'a été notée au niveau de paramètres
comme la croissance, la consommation alimentaire, la mortalité, le comportement, l'hématologie, la chimie du sang,
la composition de l'urine, le poids des organes ni la pathologie macroscopique et microscopique. La CSEO était de
50 000 ppm, soit l'équivalent de 2 500 mg/kg/jour. Le produit a été administré par incorporation dans la diète de
groupes de chiens Beagle à des concentrations de 0, 1 000 et 10 000 ppm pendant 3 mois. Aucun décès n'est
survenu pendant l'étude. Les taux de croissance et la consommation alimentaire de tous les groupes se situaient
dans les limites normales. On n'a noté aucun changement significatif dans les paramètres de laboratoire
(hématologie, chimie clinique, analyse de l'urine) et aucun changement lié au traitement n'a été noté à l'autopsie ni
à l'examen histopathologique. La CSEO était de 10 000 ppm, soit l'équivalent d'un apport quotidien moyen de 322
mg/kg/jour.
Toxicité subaiguë:
non déterminé
Toxicité génétique:
Test d'Ames: négatif
Souris dominante fatale: Negatif.
(Hamster chinois) Test d'anomalies nucléaires: Negatif.
(Hamster Chinois)
Test d`aberration chromosomique: Négatif.
(Cellules somatiques)
Test d'Ames: négatif
Test du gêne létal dominant: Non mutagène
Test des anomalies du noyau dans les noyaux de l'interphase somatique (Hamster chinois): Non mutagène.
page: 4 / 6 000000016923
Fiche signalétique
WHMIS / ANSI Z400.1-2004 Compliant
Date / mise à jour le: 01-14-2008 Version: 1.1
Produit: IRGANOX 1010
cancérogénicité:
Aucun changement connexe par traitement n'a été vu dans les points finaux mesurés, y compris la formation de
tumeur. La DSEO fut de 10,000 ppm, d'équivalent à aenviron 116 mg/kg/jour.
Aucun des composants de ce produit qui sont présents à des concentrations supérieures à 0.1% ne sont
répertoriés comme carcinogènes par IARC,le NTP, OSHA ou ACGIH.
toxicité pour la reproduction:
Le produit a été administré à des rats à des doses de 0, 1 000, 3 000 et 10 000 ppm dans l'alimentation, sur deux
générations. Aucun décès n'est survenu chez les animaux adultes des deux générations, et aucun effet durable
n'a pu être attribué au traitement. On n'a noté aucun effet indésirable sur les portées des parents traités, et ce pour
les deux générations. Les résultats de cette étude montrent que, dans les conditions de l'étude, les animaux traités
n'affichent aucune différence parrapport au groupe témoin et que leur capacité reproductive n'a pas étéaltérée.
Toxicité pour le développement/tératogénicité:
Aucune évidence d'effets teratogènes ou d'embryotoxicité chez des rats et des souris gestantes intoxiquées par
gavage à des doses de 1000 mg/kg à partir du sixième jour de gestation jusqu'au quinzième.
neurotoxicité:
Indéterminé
12. Informations écologiques
Toxicité pour les poissons:
Brachydanio rerio/96 h/CL50: > 100 mg/l (Ligne directrice 203 de l'OCDE)
Toxicité pour les invertébrés aquatiques:
Daphnia magna/24 h/CE50: > 86 mg/l (OCDE 202)
La concentration testée est bien au-dessus de sa solubilité dans l'eau
Toxicité pour les plantes aquatiques:
Scenedesmus sp./72 h/CE50: > 100 mg/l (Directive 92/69/CEE, C.3)
Toxicité sur les microorganismes:
boue activée/3 h/CI50: > 100 mg/l (OCDE 209)
Biodégradation:
Méthode d'essai: OCDE 303A
Taux d'élimination: 45 % (28 Days)
Evaluation: Éliminé
Méthode d'essai: OCDE 301B
Taux d'élimination: 5 % (28 Days)
Evaluation: Pas facilement biodégradable.
Bioaccumulation:
Ligne directrice 305 C de l'OCDE
Facteur de bioconcentration: < 2.3
13. Considérations relatives à l'élimination
Elimination du produit:
Jeter conformément au réglementations régionales ou nationales.
14. Informations relatives au transport
TDG (Canada) Transport routier
Informations spéciales pour le transport: Produit non dangereux au sens des réglementations de transport.
Association du transport aérien international (IATA)
Informations spéciales pour le transport: Produit non dangereux au sens des réglementations de transport.
page: 5 / 6 000000016923
Fiche signalétique
WHMIS / ANSI Z400.1-2004 Compliant
Date / mise à jour le: 01-14-2008 Version: 1.1
Produit: IRGANOX 1010
Code maritime international pour le transport des marchandises dangereuses (IMDG)
Informations spéciales pour le transport: Produit non dangereux au sens des réglementations de transport.
15. Informations réglementaires
Canada: Liste Domestique De Substances (DSL): Toutes les composantes y figurent ou
sont exemptées au DSL
USA: Loi au contrôle de substances toxiques (TSCA): Toutes les composantes que contient
ce produit sont soient exemptées ou
inscrites au répertoire du TSCA.
Réglementation Canada
Système d'inform. sur les matières dangereuses utilisées au travail (SIMDUT Classification):
Ce produit n'est pas réglementé par le SIMDUT.
Nouvelles activités (Nac):
Ce produit ne contient aucune composante qui est soumise à un Avis de nouvelle activité
Règlements international
Chemical Weapons Convention (Convention sur les armes chimiques):
Ce produit ne contient aucune composante inscrite sur les listes de produits chimiques du CWC
16. Autres informations
Personne contact pour la sécurité du produit:
Préparé par: Terence Ma (905) 812-7280
Date / mise à jour le: 01-14-2008
Ce produit a été classé en accord avec les critères de risques du règlement sur les produits contrôlés, et les fiches
signalétiques contiennent toute l'information requise par le règlement sur les produits contrôlés.
Avis de non responsabilité:
Avis de non responsabilité L'information ci-jointe est basée sur des données jugées correctes. Aucune garantie,
expresse ou implicite, n'est basée par rapport à ces données ou cette information. L'utilisateur est responsable de
déterminer si le produit convient aux conditions d'utilisation prévues.
FIN DE LA FICHE DE DONNÉES DE SÉCURITÉ
page: 6 / 6 000000016923